- 2016 dodge 2500 5mph max in 100 mi service def system manual#
- 2016 dodge 2500 5mph max in 100 mi service def system full#
- 2016 dodge 2500 5mph max in 100 mi service def system software#
- 2016 dodge 2500 5mph max in 100 mi service def system code#
Problem usually goes away after a couple of fuel fills." I have had this issue before and spent $700+ to have the fuel sensor replaced.
2016 dodge 2500 5mph max in 100 mi service def system full#
When the fuel tank is full it registers, but sometimes when it is half full it will register as empty, and the yellow warning light will come on. "I have had problems with my fuel sensor not working. "Fuel cap caused the truck to fall the emissions test the first time I had to take one which was when the truck was 3 years old"
2016 dodge 2500 5mph max in 100 mi service def system code#
Getting tired of having dealer clear the code but system will not remote start with the check engine light on" Vehicle will not stop giving the gas cap code. "Replaced gas cap to stop check engine code. "This problem was caused by an inquisitive chipmunk chewing the robber house on top of the gas tank." I can say we are grateful that we got the 200 mile warning rather than just having the truck stop running or not restart." $2800 later ($1000 for the rental and $1800 for the repair) we picked up the truck. On Tuesday morning the dealership called and said we needed a DEF pump and luckily they had one in stock. Then we rented the only available car at the local airport (thankfully right next door) for $250/day and continued to our destination (another 100 miles). We drove 100 miles to the nearest dealership and left the truck there. It was Christmas Eve, a Sunday, and we were in an area with no Dodge dealerships where we could leave the truck. "On a trip in the mountains of Colorado we got a warning on the dash that we needed to service the DEF system and the vehicle would not restart in 200 miles. Very good engine:3.0 ecodiesel but poorly trained mechanics at dealer." PCM replaced a second time then drove 20,000 miles in 3 months, no problems except mpg reduced 17%. 5 trips to dealer for repair, finally called Chrysler who got the PCM replaced only to have it fail & cause dead truck 3 miles down the road due to inappropriate replacement procedure. "PCM malfunctioned, indicated failure of emission sensor. I plan to take it in soon for further diognostics" This time the check engine light turned off on it.s own. "set code for exhaust sensor malfunction 2 years ago a similar problem required replacement of the Primary Control Module(PCM). "The entire diesel emission control system of the vehicle needed to be checked at the dealer 4 times and then was completely replaced on warrantee, because it was becoming too cold and plugging resulting in diesel fumes in the cab." "Recall in effect since vehicle has problem with emission controls for diesel engine." Also the DEF stopped working and needed replacing as well as the DEF injector." Then several emissions sensors needed to be replaced.
"The diesel particulate filter needed regenerating. After fixing the emissions issues to comply with the EPA guidelines, my fuel economy went down 3-4 mpg. I had the vehicle back to the dealer for 2 EPA recalls concerning the diesel emission issues. "The problem was not the emissions system, but it was the US Government compliance with EPA diesel emissions. "caused the check engine light to come on but caused no drivabiliy poroblems. Repair times were grossly excessive due to parts not being available from FCA." Second failure resulted in coolant loss requiring truck to be shut down. First failure melted plastic upper intake manifold disabling truck. had to change twice the urea injector and the catalysor!!"
The urea is freezing when it`s very cold, i.e. "In winter the anti pollution system has problem. "The computer needed a relash and the cat was replaced"
2016 dodge 2500 5mph max in 100 mi service def system manual#
This required reprograming of the software, a manual de-sooting of the filter and replacing associated sensors. "The DEF system needed unscheduled servicing. After dealer replaced DEF injectors, truck has been fine" "Check Engine Light - First misdiagnosed as incorrect DEF fluid then after flushing and refilling, then light returned. Not a big deal, truck always ran fine, dealer handled well" "This vehicle has not experienced difficulty, but was involved in the recall." The emissions system issues have, so far, been covered by an extended warranty" Since the "fix" for the cheating, we have had numerous problems including reduced mileage and various emissions system issues. "This is an EcoDiesel, which was the subject of a settlement regarding emissions cheating. Mine never leaked, but the recall replaced it, Free"
2016 dodge 2500 5mph max in 100 mi service def system software#
"The truck was recalled twice to revise control software and emissions hardware" "The def system has constant problems including the def pump and injector problems."
0 kommentar(er)
